Sweep & inspection
Caps & crowns
Flue relining
Masonry repair
Gas fireplace serviceLevel 1 sweep and inspection to the NFPA 211 annual standard - flue, crown, cap, and flashing checked and photographed
Chimney sweep logs do not sweep chimneys. They loosen some creosote - which then falls where a brush and vacuum still have to collect it.
Chimney Company in Lyons, IL
Chimney repair in Lyons usually means working on a coal-era brick flue that’s been retrofitted for gas appliances, and that’s where most problems start. The original clay tile liners in these 1920s bungalows and two-flats were sized for coal smoke, not the continuous exhaust of a modern high-efficiency furnace. When you add a century of Chicago freeze-thaw cycles to that setup, you get cracked crowns, spalled brick, and liners that can’t keep up. Call Sandstone Chimney Sweep at (833) 589-7835 when you need a repair that actually matches the age and condition of your Lyons home.
Why Lyons Homes Are Different
Lyons is a village of roughly one square mile on the Des Plaines River, and that compact geography shapes nearly every chimney job we do here. The housing stock dates mostly from the pre-war boom: brick bungalows, American Foursquares, and attached two-flats, many of which still have the original exterior masonry chimneys that once served coal furnaces. Later, those same flues got gas furnaces and water heaters tied in, usually with clay tile liners that were never resized for the new appliances.
What that means in practice: nearly every chimney we inspect in Lyons has a liner that’s technically too small or already cracked for today’s venting requirements. The shared chimneys between attached two-flats make it worse, two separate heating systems venting into one masonry mass means one neighbor’s repair often affects the other’s flue. And because the village is so tight, roof access usually means working around narrow side yards, low overhangs, and chimneys that sit only a few feet from the next building. Humidity off the Des Plaines River speeds up crown and mortar decay, so we see surface damage here that you won’t find a mile up the ridge in Brookfield or North Riverside.
Styles & brands we work with
Our Main Lyons Services
The two services Lyons homeowners call about most are chimney sweeping and dryer vent cleaning, both of which address the village’s oldest and most common fire hazards in a single visit when you schedule them together.
Chimney Sweep in Lyons
A proper sweep in Lyons starts with understanding what you’re burning and what the flue was built for. We remove creosote and soot buildup from the flue walls and smoke chamber, then run a camera inspection to check the liner, mortar joints, and crown before we finish. Because most flues here are coal-era clay tile that’s been pushed well past its design life, the inspection often turns up hairline cracks that would go unnoticed anywhere else. We’ll show you the footage and explain what it means. Chimney Sweep in Lyons
Dryer Vent Cleaning in Lyons
Dryer vents in Lyons two-flats and bungalows typically run through basements and out narrow side walls, and lint collects in those long, low-clearance runs faster than homeowners expect. A clogged vent makes your dryer run hotter and longer, and that heat has nowhere to go. We clean the full vent run from the dryer to the exterior cap, including the areas other companies skip because they’re hard to reach in these older homes. Two fire hazards, one visit. Dryer Vent Cleaning in Lyons
What happens when you call
- 1
A real person answersNo phone trees — you reach a local pro.
- 2
You get an upfront price rangeHonest numbers before anyone is dispatched.
- 3
A background-checked tech heads outLicensed & insured, dispatched right away.
- 4
You approve before work beginsNothing starts until you say go.
Chimney Repair in Lyons
Chimney repair in Lyons is almost always a story about water and time. The freeze-thaw cycle here is relentless: summer storms soak into the brick and mortar, winter freezes it, and the expansion cracks caps, crowns, and flue tiles from the top down. Add to that a clay liner that was sized for coal in 1925 and has been running a gas furnace every winter since, and you have a system that’s quietly failing even when the fireplace still drafts fine. We find it, we fix it. Chimney Repair
Chimney Cap Installation
Signs you need it
Water staining on the ceiling near the chimney, rust on the damper, or birds and debris falling into the firebox are all signs your flue has no cap or a failed one.
What it costs in Lyons
Chimney cap installation in Lyons typically runs $210 – $390 depending on the flue size and whether the existing crown needs prep work.
How we do it
We measure the flue tile, select a properly sized cap, and secure it to the crown with mechanical fasteners so it stays put through Lyons wind and ice.
Chimney Cap Replacement
Signs you need it
A cap that’s rusted through, missing its mesh, or has blown off the roof entirely is no longer keeping rain and animals out.
What it costs in Lyons
Replacing a failed cap in Lyons costs $230 – $410, including removing the old unit and fitting the new one to your specific flue dimensions.
How we do it
We remove the damaged cap, inspect the crown underneath for hidden water damage, and install a new cap sized exactly to your flue tile.
Chimney Liner Installation
Signs you need it
Cracked flue tiles visible during a camera inspection, falling mortar pieces in the firebox, or a gas appliance that’s venting poorly all point to a liner that’s no longer holding.
What it costs in Lyons
Chimney liner installation in Lyons typically ranges $2,000 – $4,900 depending on flue length and whether we’re relining a single-flue bungalow or a shared two-flat chimney.
How we do it
We size the liner to your appliance’s BTU output, feed it down the flue, and insulate the void so the liner can handle continuous winter use without condensation damage.
Chimney Flashing Repair
Signs you need it
Water staining on the ceiling or walls where the chimney meets the roofline means the flashing has separated and is letting moisture behind the shingles.
What it costs in Lyons
Flashing repair in Lyons runs $340 – $670, with tighter two-flat roof access pushing some jobs toward the upper end of that range.
How we do it
We remove the old flashing, check the underlying roof deck for rot, and install new step and counter flashing that moves water away from the masonry joint.
Chimney Crown Repair
Signs you need it
A crown with visible cracks, missing chunks, or standing water on top of the chimney is actively letting moisture into the masonry structure below.
What it costs in Lyons
Crown repair in Lyons typically costs $390 – $760 depending on crown size and whether we can patch it or need to recast the full surface.
How we do it
We torch-clean the old crown surface, fill the cracks with a cement-based crown patch, and build a proper overhang so water drips away from the brick.
What Chimney Repair Costs in Lyons
| Item | Typical range in Lyons |
|---|---|
| Chimney cap installation | $210 – $390 |
| Chimney cap replacement | $230 – $410 |
| Chimney liner installation | $2,000 – $4,900 |
| Chimney flashing repair | $340 – $670 |
| Chimney crown repair | $390 – $760 |
Prices in Lyons run higher than in some newer suburbs because of the access challenges: tight side yards, shared chimneys, and roof lines that sit close to the neighboring two-flat. You’ll get a flat price before any work begins, and we don’t add charges for the camera inspection or the roof access planning.
How often should I have my Lyons chimney repaired or inspected?
Annual inspection is the right interval in Lyons, even if you only burn a few fires each winter. Gas furnaces venting through coal-era flues can develop cracks within a single heating season, and the village’s humidity and freeze-thaw cycles accelerate any existing damage. A camera inspection each year catches liner cracks before they become a repair that costs thousands.
Do I really need a new liner, or can it just be patched?
The answer depends on what the camera shows, and we’ll show you the footage before we recommend anything. A single hairline crack in a tile that’s otherwise sound might be patchable with HeatShield. A liner system that’s collapsed, separated at the joints, or sized wrong for your appliance needs replacement with a properly sized DuraFlex system. We don’t sell liner jobs that the video doesn’t support.
Brands We Service in Lyons
We work with the product lines that certified chimney professionals specify: DuraFlex liner systems, HeatShield resurfacing materials, and Famco caps and components. We’ll recommend the right system for your Lyons flue, not whatever ships cheapest. See our brands for the full list.
See the difference
Before
After
Before
After
Before
AfterPricing for Chimney Company in Lyons, IL
| Service | Typical range in Lyons |
|---|---|
| Chimney sweep with inspection | $169 – $450 |
| Dryer vent cleaning | $99 – $210 |
| Chimney cap installation | $210 – $390 |
| Chimney cap replacement | $230 – $410 |
| Chimney liner installation | $2,000 – $4,900 |
| Chimney flashing repair | $340 – $670 |
| Chimney crown repair | $390 – $760 |
| Masonry repair (spot tuckpointing) | $280 – $650 |
| Smoke chamber parging | $550 – $1,300 |
| Chimney repointing (partial rebuild) | $640 – $1,500 |
The biggest price drivers in Lyons are liner condition and roof access; a tight side yard that requires staging setup adds time, and a shared two-flat chimney may mean coordinating with the neighbor’s unit even when the flue is separate. Whatever the scope, you’ll get the complete price before we start, and there’s no charge for the camera inspection that backs up our recommendation.
Neighborhoods We Serve in Lyons
We work throughout Lyons, from the riverside streets west of Harlem Avenue to the bungalow blocks east of Lawndale and the two-flat corridors along 39th Street and Ogden. The whole village is within a mile or so of each other, and we usually schedule sweeps and inspections in Lyons within a few days of your call.
- Riverside district along the Des Plaines River
- West End, near the Brookfield border
- Bungalow blocks off 39th Street
- Two-flat corridors along Lawndale and Center Avenues
- North Lyons, toward Ogden Avenue
Service Area – Cities Near Lyons
Sandstone Chimney Sweep serves homes across the near west suburbs, including Brookfield, IL, North Riverside, IL, Riverside, IL, and Berwyn, IL. Many of these neighboring villages have the same pre-war housing stock and the same freeze-thaw challenges, so our Lyons crews are familiar with the local venting codes and the typical chimney configurations you’ll find across the area.
Serving Lyons, IL — Our Local Coverage Area
We’re based in the Lyons area and know this community well. Use the map below to see our service coverage — if you’re nearby, we can almost certainly help.
FAQs About Chimney Company in Lyons
We typically schedule Lyons chimney work within a few days of your call, and we can often accommodate urgent liner inspections faster if you’re seeing water in the firebox or suspect a blockage. Call (833) 589-7835 and we’ll give you a straight answer on availability.
Most chimney sweeps, caps, and liner repairs don’t require a permit in Lyons, but a full rebuild or structural repair may need village approval. We’ll tell you what applies to your job before work starts, and we handle the paperwork when it’s needed.
Yes. We inspect and repair shared chimneys across attached two-flats in Lyons regularly, and we know how to work with both units’ flues without disrupting the other side. We’ll advise you if the repair scope involves the neighbor’s portion of the masonry wall.
If you’re in Lyons and you need a chimney swept, inspected, repaired, or a dryer vent cleaned, call Sandstone Chimney Sweep at (833) 589-7835 for a free estimate. We’ll show you exactly what’s going on inside your flue before we recommend any work, and we’ll stand behind what we fix.
What happens when you call
- 1A real person answersNo phone trees — talk to a local chimney cleaning pro.
- 2You get an upfront price rangeHonest numbers before anyone is dispatched. No surprises.
- 3We come out and measureLicensed & insured, at a time that suits you — the visit and the quote are both free.
- 4You get the price in writingLine-itemed, yours to keep, and nothing starts until you say go.
What Lyons Customers Say
"Liner was cracked in two places. He walked me through the repair options honestly, including the one that was cheaper for him and better for me."
— Amanda Hayes"Swept it, capped it, and installed a proper damper. The downdraft smell in the summer that we'd lived with for years is gone."
— Emily Meyer"Thorough sweep and a clear report. He was running late from the job before and arrived near the end of the window, though he did call to warn me."
— Steve Mercer